* BP to appeal ruling over blame for disaster
* Judge has yet to assign damages from spill
* BP shares fall 5.9 percent in U.S. trading (Adds quote on heightened liability risks for energy sector, paragraphs 9-10)
By Anna Driver and Mica Rosenberg
HOUSTON/NEW YORK, Sept 4 (Reuters) - A U.S. judge has decided that BP Plc was "grossly negligent" and "reckless" in the Gulf of Mexico oil spill four years ago, a ruling that could add nearly $18 billion in fines to more than $42 billion in charges the company took for the worst offshore environmental disaster in U.S. history.
BP said it would appeal Thursday's ruling by U.S. District Judge Carl Barbier in New Orleans, Louisiana, who held a trial without a jury last year to determine who was responsible for the April 20, 2010 rig explosion and spill that killed 11 workers and spewed oil for nearly three months onto the shorelines of several states.
Barbier ruled that BP was mostly at fault and that two other companies in the case, Transocean Ltd and Halliburton , were not as much to blame. The disaster struck when a surge of methane gas known to rig hands as a "kick" sparked an explosion aboard the Deepwater Horizon rig as it was drilling the mile-deep Macondo 252 well off Louisiana.
Barbier has yet to assign damages from the spill under the federal Clean Water Act or rule on how many barrels spilled, but David Uhlmann, a University of Michigan law professor and former chief of the Justice Department's environmental crimes section, said the ruling "dramatically increases" BP's liability for civil penalties under the act.
Previous calculations by Reuters have shown fines could run to $17.6 billion in the costliest scenario under a 'gross negligence' finding. The amount is far more than the $4.5 billion maximum fine that could have been levied under a simple 'negligence' ruling.
BP has set aside only $3.5 billion for fines under the Clean Water Act, part of a much broader series of provisions for cleanup, compensation and damages that exceed $42 billion.
"The Court concludes that the discharge of oil 'was the result of gross negligence or willful misconduct' by BP," Barbier said in his written ruling. "BP's conduct was reckless."
In response, BP said it would challenge the ruling because it believes the standard for proving "gross negligence" was not met. "BP believes that an impartial view of the record does not support the erroneous conclusion reached by the District Court."
If the gross negligence ruling stands, it could create a tough new standard and raise liability risks for the deepwater drilling and other high risk industries, legal and business experts said.
There will be "long-term repercussions," Gianna Bern, who teaches international finance at the University of Notre Dame, said of the energy sector. "Potential liability is now in the stratosphere and that limits the number of players that can engage in this type of activity."
Shares of BP in the United States closed down 5.9 percent at $44.89. BP shares in London also closed down nearly 6 percent, the worst one day slide in more than four years.
A separate criminal case was settled with the U.S. government in late 2012. BP agreed to pay $4.5 billion in fines.
Even after the Clean Water Act fines are set, BP may face other bills from a lengthy Natural Resources Damage Assessment, which could require BP to carry out or fund environmental restoration work in the Gulf, and other claims.
DIVIDEND SAFE FOR NOW
The case will go on for months or even years with Barbier set to assign damages after the next phase of a civil trial over the accident, scheduled for January 2015. The two earlier phases of the trial looked at how to apportion blame and examined how much oil spilled.
BP has been forced to shrink by selling assets to pay for the cleanup. Those sales erased about a fifth of its earning power and it may be pressured by investors to delay making new investments until the lawsuit is resolved.
In addition to the court case, Philip Adams, analyst at Gimme Credit, said BP is vulnerable to growing tensions between the West and Russia. London-based BP holds a 19.75 percent stake in Russian energy giant Rosneft.
Still, the company had $27.5 billion in cash and equivalents on its balance sheet at the end of the second quarter, and analysts think it will keep paying dividends that yield about 5 percent.
Jason Gammel, an equity analyst at Jefferies in London wrote that even with a maximum fine, BP has sufficient liquidity to meet its obligations. "We would expect a lengthy appeals process first. We thus do not believe there is risk to the current BP dividend."
Under federal rules, a gross negligence verdict carries a potential fine of $4,300 per barrel, far higher than the statutory limit on a simple "negligence" of $1,100 per barrel.
BP says 3.26 million barrels leaked from the well and the U.S government says 4.9 million barrels spilled. The fines will exclude about 810,000 barrels collected during cleanup.
The judge apportioned 67 percent of the fault to BP, 30 percent to Transocean, which owned the drillship, and 3 percent to Halliburton, which did cement work on the Macondo well.
Transocean and Halliburton have settled some liabilities and the judge said they were shielded by indemnity clauses with BP. Texas-based Anadarko Petroleum Corp, which owned a quarter of the well, might have to pay fines under the Clean Water Act, though it has settled other claims with BP.
Gulf Coast states would receive a portion of any fines BP pays to the government.
On Thursday, U.S. Attorney General Eric Holder said in a statement, "We are confident this decision will serve as a strong deterrent to anyone tempted to sacrifice safety and the environment in the pursuit of profit."
The civil case is In re: Oil Spill by the Oil Rig "Deepwater Horizon" in the Gulf of Mexico, on April 20, 2010, U.S. District Court, Eastern District of Louisiana, No. 10-md-02179. (Additional reporting by Sudip Kar-Gupta, Karolin Schaps and Karey Van Hall; Writing by Terry Wade; Editing by Grant McCool)
Our Standards: The Thomson Reuters Trust Principles.